Business Dump - Home Improvement

One of the most frustrating problems with a window air conditioner is if it starts to ice up. For the owner of the air conditioner is can be perplexing.

When this problem occurs most people immediately think it is the fault of the refrigerant gas. More often the cause is the result of other difficulties.

It

According to USFDA, a combination product is one composed of any combination of a drug and device; biological product and device; drug and biological product

is most often the result of poor airflow.

Any time the airflow through an air conditioner is restricted the cooling system becomes affected. If taken to extremes the critical pressure-temperature balance of the cooling coil can be changed. If they drop too low the cooling coils surface temperature can drop be

; or drug, device, and biological product and fixed dose combination would include two or more combinations of drug.

Examples of combination products may in

low the dew point temperature of the room. When this happens the cooling coil will begin to operate as a refrigerator rather than an air conditioner. Rather than simply cooling the air it will collect and hold moisture. The moisture will freeze onto the cooling coil where it will appear as ice.

The primary jo

lude drug-coated devices, drugs packaged with delivery devices in medical kits, and drugs and devices packaged separately but intended to be used together.

of an air conditioner is to de-humidify, not refrigerate, the room air. By removing the moisture from the room air it gives us a feeling of comfort. To do this though the temperature of the cooling coil must always be higher than the room’s dew point. If it is allowed to drop below the dew point the air condi

here is enormous increase in the number of combination products entering the market in the recent years. Combination products have proven advantages but fixe

tioner will start to produce ice.

With this information in mind the following are a few problems that can result in your air conditioner icing up:

1. Dirty filter. To avoid this replace or clean your filter every couple of weeks of the cooling season. If a smoker do it every week. To clean filter remove fro

d dose combinations are still in the process of convincing regulatory authority on their advantages over the single ingredient formulations.

Combination pro

air conditioner, wet thoroughly, and lay in bottom of a sink. Sprinkle detergent (laundry detergent works well) onto filter surface. Allow to sit for a few minutes. Add warm water to sink so that filter is completely covered. Soak for 15 minutes. Remove from water and rinse. Allow to air dry.

2. Dirty or bl

ucts have become life saving products for the pharmaceutical companies who doesn’t have many innovative molecules in their product pipeline and have been inc

ocked cooling coil. An air conditioner requires regular maintenance. Usually every two or three years. Every year would be best, but this can be costly unless you do it yourself. During cleaning the cooling coil should be degreased and washed to remove accumulated dirt and debris. Degreasing is important to r

easingly used in the product life cycle management. Even the companies having product patents are trying to extend their product life cycle through the combi

emove any coatings on the coil. If not done greasy residue can trap and hold air borne particles. They will build up on the coil and affect heat transfer. If left too long this can result in the cooling coil becoming partially blocked. This will produce a lower airflow.

3. Dirty or blocked condenser coil. Th

nation products and maximize the revenues. But the companies involved in this practice are overlooking that they are burdening the patients both economically

condenser coil is the one at the rear of the air conditioner. Its job is to dissipate the heat that is being removed from the room. Just like the cooling coil it too must be cleaned every few years. Since the condenser is on the outside of the home it becomes exposed to a lot of dirt, pollen, and smog. Since

and physically. They need to rightly judge the benefits of the combination products and they have to even look at the risks involved when combining the produ

airflow direction is from inside to outside it is the inside surface of the condenser that becomes dirty. Therefore to clean this part the air conditioner must be completely disassembled. If not cleaned regularly an airflow blockage here can even burn out the compressor. Before this happens though the lowering

ts. Some of the combination products were well accepted by physicians while others suffered. Companies involved in development of combination products are fi

of airflow will affect the overall operation. This can result in the compressor efficiency dropping, the internal pressure-temperature relationships being affected, and the resultant production of ice on the cooling coil.

4. Inefficient compressor. As describe above an inefficient compressor can cause icing

ding difficulty in defining their combination products and facing various challenges from selecting a combination to marketing it.

Following aspects would a

up. If the compressor is not able to pump the refrigerant properly the cooing coil may not get cold enough to shut off the cold control. It can hover just above the cut off point. When this happens the cooling coil will begin to refrigerate. Ice on the cooling coil will result. If the compressor itself is at f

dd to the challenges in developing combination products:

Which markets to tap where the combination products can do fairly well?
Which combination prod

ault the air conditioner will have to be replaced. But note that many icing problems are misdiagnosed as bad compressors when they were actually one of the other faults discussed in this article.

5. Not enough refrigerant. Too much refrigerant. Both scenarios can result in and icing condition. If your air co

cts are meaningful and rational?
Which therapeutic categories to select?
Which Combinations can address unmet needs of the patients?
Do combin

ditioner was repaired recently suspect too much refrigerant. Mixed with an airflow problem this can be difficult to diagnose. If not repaired recently then suspect airflow problems before considering a refrigerant imbalance.

6. Outdoor temperature too low. Icing can occur if the outside temperature falls bel

tions increase the patient compliance?
What would be the developing cost?
How to tackle the risks encountered during combination product developmen

ow 60 Degrees Fahrenheit. If the outside temperature is too low the air conditioner pressure-temperatures can be affected. When the outside temperature falls the cooling coil temperature will also fall. So much that the coil will refrigerate the room air. This will result in the cooling coil beginning to produ

t?

As combination products don't fit into the traditional categories of drugs, medical devices, or biological products, the USFDA is in the process of devel

e ice. This problem is more prevalent in the fall. If it is hot during the day but cold at night suspect this problem as the cause of icing up. If this problem is suspected try running the air conditioner in the fan only position. Leave the re-circulating vent open. This will circulate the room air without coo

ping new procedures for reviewing their safety, efficacy and quality.

Professional from academic institutions, pharmaceutical industries, health care indust

ling it, while bringing in a small amount of outside air during the night.

7. Oversized air conditioner. If the air conditioner is too large for the room size icing up can result. If oversized the air conditioner can short-cycle. This condition is usually seen as the air conditioner starting and stopping eve

y and representatives from various regulatory agencies are working out to design the regulatory requirements for manufacture and sale of combination products

ry few minutes. Even though it runs almost constantly the air conditioner will give poor cooling. Use a sizing chart to determine what is the proper air conditioner size for that particular room.

8. Cold control not shutting off. If the cold control does not shut off the cooling coil surface temperature will

.

As there is an increasing trend of the combination products companies manufacturing such products should be able to tackle the problems involved in the de

rop below the room’s dew point and begin to refrigerate. This will allow ice to build up onto the cooling coil.

9. Cold control bulb broken or loose. As in the previous paragraph this will result in the cold control not shutting off and ice to build up on the cooling coil. If this is suspected remove the fron

elopment. They need to be wiser in analyzing the market trends and the regulatory requirements.

Companies that provide selfless information through particip

t grille and inspect the bulb. If broken replace cold control. If bent, kinked, or not securely fastened suspect a problem here.

Also check out our other related articles about air conditioners:

How to Clean your Air Conditioner like a Pro

How to Size an Air Conditioner

Placement of a Window Air Conditione

tion in industry events and feedback to regulatory authorities would be able to face the challenges and will be successful in developing combination products

HTTP = HTML link (for blogs, profiles,phorums):
<a href="http://www.businessdump.org.ua/article/344433/businessdump-Why-Window-Air-Conditioners-Ice-Up.html">Why Window Air Conditioners Ice Up</a>

BB link (for phorums):
[url=http://www.businessdump.org.ua/article/344433/businessdump-Why-Window-Air-Conditioners-Ice-Up.html]Why Window Air Conditioners Ice Up[/url]

Siesta Key formerly called Sarasota Key. It was Harry Higel, a fiery outspoken man who was involved in bitter political fights, who gave Siesta Key its name.

The fluid-filled sac, which usually develops on the surface of an ovary, is a problem that affects many women. This is also called the ovarian cyst, and there are known a lot of different types

Tags

Links

Business Dump - Why Window Air Conditioners Ice Up

Related Articles: